The opportunity of technological and modified lignosulphonate wastes, process water, oxygenized brown coal with high content huminic acid (to 60 %) with alkali usage as plasticizer agent in the coalwater slurry (CWS) production technological process was checked. The CWS stability scheme in alkali additives interaction was suggested. The ...
Dispersants, serving as an essential raw material in the formulation of coal water slurry, offer an economical and convenient solution for enhancing slurry concentration, thus stimulating significant interest in the development of novel and efficient dispersants. This paper intends to illuminate the evolution of dispersants by examining both the traditional and the newly conceived types and ...
Coal slurry is a mixture of crushed coal and a liquid such as water or oil. The traditional mixture, first patented in England in 1891, consists of 50 percent coal and 50 percent water by weight. Socalled heavy coal slurries or slurry fuels consist of.. Other articles where coal slurry is discussed: coal utilization: Coalwater slurry fuel ...
the 1980s. The largest producer and user of slurry fuels (Coal Water Slurry, CWS) is China [3]. Despite of several decades of CWS research history, investigations are still carried out to improve the parameters of disperse fuels and to improve the combustion of these fuels. The close relationship between the properties of slurry fuels and number of
Fig. 1 shows the production process of BDO tar [7]. ... Some chemical wastes mix into coalwaterslurry (CWS) in a proportion known as wastecoalwaterslurry (WCWS), which can control waste releases and recycle valuable resources. With the development of the gasification technology of CWS, the adaptability of raw materials is continually ...
The prepared coalwater slurry consisted of 23% to 50% Lochiel coal and 40% Bowman's coal. The authors found that the solid concentration a ff ected the nature of the slurry, with 23% Newtonian
In terms of energy consumption, the electrolysis of coal is preferred to water electrolysis; this is because kcal of electrical energy and a reversible potential of V are required to produce 1 mol of hydrogen in water electrolysis, whereas coal electrolysis only requires kcal and V, respectively. 16,17 This is achieved because the oxygen evolution reaction, which has high ...
Abstract. In this paper, based on Fluent software, a fivenozzle gasifier reactor was established to simulate the gasification process of oilbased drill cuttings coalwater slurry. The influence of concentration and oxygen/carbon atomic ratio on the gasification process of oilbased drill cuttings coalwater slurry was investigated.
Coalassisted water electrolysis for hydrogen production can effectively reduce electricity consumption and improve the economics of electrolytic hydrogen production technology. However, the influencing factors of this process, especially the mechanism of the electrolyte itself on the coal particles, are not clear.
The headloss characteristics of the fine (<53 μm) particulate coal water slurry are presented in Fig. 13. The headloss characteristics of the fine particulate coal water slurry is also compared with those of normal tap water. The headloss of the water is found to increase with increase in the flow velocity from to m/s.
In this work, the pyrolysis behavior of coalwater slurry and coaloilwater slurry at various temperatures of °C in a fixed bed reactor was studied. For the pyrolysis of coalwater slurry and coaloilwater slurry, the increase of pyrolysis temperature and water content promoted an increase in gas production but resulted in a ...
Dispersants are chemical moieties that modify interfacial characteristics by adsorption at the solidliquid interface, and they have been widely used in modern industrial production. This review focuses on the research and perspectives of anionic dispersants for coalwater slurry (CWS). Various common anionic dispersants are briefly summarized, including natural and synthetic species. The ...
In the production process, noncompliant wastewater was treated and reused in industrial production, which can greatly reduce the consumption of fresh water and lessen pollutant emissions [4], [5]. Coal water slurry (CWS) [6], [7] refers to a suspended dispersion system containing coal, water and a small amount of additives.
The average size of fuel droplets in the jet decreases by 512% in comparison with twocomponent coalwater fuel. Ignition delay time of a single droplet of slurry at oxidizer temperature 1273 K increases by 23% in comparison with twocomponent coalwater fuel when 10% of coal is replaced by liquid pyrolysis products.
It was found that activation energy of conversion is E = 103 kJ/mol and the preexponential factor is A0 = × 10 s 1. It was revealed that coal gasification in SCW without oxidants is the weakly endothermic process. The addition of CO 2 into SCW decreases the conversion rate and increases the CO yield.
This phenomenon is not conducive to the stable operation of the actual industrial production process. Thus, we first selected appropriate additives through experiments to ensure that the two highconcentration organic waste liquids can form a uniformly dispersed liquid. ... Coalwater slurry is a costeffective new technology to treat organic ...
The three technology categories are considered as the "pulping", "pumping" and "endprocessing". The "pulping" category addresses technologies related to the production process of coalwater slurry. The "pumping" category addresses technologies related to the transport of coal slurry along a pipeline to its destination.
A total of eight types of organic wastewater were used in the study. Gas washing water (A), sulfur water (B), carbonized water (C) and slag discharge water (D) were the coal gasification wastewater produced by the entrained bed process; Yima wastewater (F) was coal gasification wastewater produced by the crushed coal fixed bed process (Lurgi furnace); coking wastewater (E) was produced by the ...
The whole process were as follows: firstly JDCS was crushed and milled into fine particles with d 90 less than 100 μm, for gaining a higher dissociation rate between organic rocks and minerals, because most of minerals were embedded in coal with particle size of 150 μm. 26 Then the surface of fine coal particles was selectively modified by wt% of C11C17 alkanes (to enhance the ...
To improve the efficiency of the gasification or combustion process of coal water slurry (CWS), it is significant to optimize the rheological properties and increase the solid concentration of CWS. Particularly, preparing CWS from low quality coal remains a peculiarly intriguing subject due to the large reserve and low price of low quality ...
Abstract. Coalassisted water electrolysis can reduce the electricity consumption of traditional water electrolysis by 4060%, but the rate of hydrogen production in this process is very slow. Some coal gasification wastewater can promote the electrical oxidation of coal, the addition of which can achieve resource utilization of wastewater ...
Technical Report: A highquality coalwater slurry production process. Final report. A highquality coalwater slurry production process. Final report. Full Record; Other Related Research; Authors: Rajchel, M Publication Date: Wed May 05 00:00:00 EDT 1993
© DZCrusher - كل الحقوق محفوظة
